Quarry dust, High performance concrete, Sand, Steel fibre, Silica fume. Reference 1. ACI 211.4R-93 Reapproved 1998, Codel provision. 2. Anitha selva sofia.S.D, Gayathri.R and Swathi.G Experimental investigation on quarry dust concrete with chemical admixture, Int. Journal of Latest Research in Science and Technology, Vol-2, issue-2 ...
Dec 01, 2020 Therefore, this research was to observe the possibility of quarry dust to be included in a concrete mix. The quarry dust has been used as a partial replacement for cement proportion at different levels of replacement 25, 30 and 35. Quarry dust was used as the main material in this project to measure the effectiveness of concrete performance.
An Experimental Study on Quarry Dust as a Fine Aggregate for Making a Concrete. D. Sathyapriya 1, G. Alagar Raja 2, K. Raguram 3, S. Elayabarathi 4, M. Arunkumar 5 Asst professor 1Dept of Civil Engineering, Sri Rangathar Institute of Engg and Tech, Coimbatore, Tamilnadu. UG Student 2,3,4,5 Dept of Civil Engineering, Sri Rangathar Institute of Engg and Tech, Coimbatore, Tamilnadu.
Objectives In the present study, by-product of stone crushed, quarry dust is replaced as a fine aggregate with 20, 30, 40, 50 replacement.MethodsAnalysis The fine aggregate is being replaced with fine aggregate and the compressive strength is determined for the concrete by testing the sample cube. The properties such as the specific gravity, fineness modulus, moisture content etc. are ...
May 01, 2017 Title Investigating Strength Properties of Geopolymer Concrete with Quarry Dust Authors A. Muthadhi and V. Dhivya Publication Materials Journal Volume 114 Issue 3 Appears on pagess 355-363 Keywords Class C fly ash compressive strength geopolymer concrete quarry dust Date 512017 Abstract To address the environmental constraints due to cement production and
quarry dust also contains a similar property of river sand. quarry dust is used in concrete to minimize the demand of river sand. maximum exploitation of sand is to be minimized to protect the river beds, shore structures from erosion. to reduce disposal and pollution problems emanating from
This experimental study presents the variation in the strength of concrete when replacing sand by quarry dust from 0 to 100 in steps of 10. M20 and M25 grades of concrete were taken for study keeping a constant slump of 60mm. The compressive strength of concrete cubes at the age of 7 and 28 days were obtained at room temperature. Also the temperature effect on concrete cubes at 100 o C on ...
the title of the work and journal citation in the form of a proper scientific referencing. PROPERTIES OF MICRO FINE QUARRY DUST CONCRETE NUR HANANI ABDUL RAHIM1, KARTINI KAMARUDDIN2, HAMIDAH MOHD SAMAN3 1, 2, 3 Universiti Teknologi MARA UiTM, Shah Alam, Selangor, Malaysia Index Terms Micro Fine Quarry Dust Cement Replacement Compressive Strength
The replacement percentages of Cement with GGBS are 20 , 40 and 60 by weight and 25 , 50 , 75 and 100 of Quarry Dust are used as a replacement of Natural Sand. Various combination of GGBS and Quarry Dust were prepared using M30 Grade of Concrete.
construction work. Quarry dust is produced from crusher unit and each crusher unit is produced nearly 22 to 27 of dust. This dust is completely waste material for crusher unit but quarry dust is useful for construction work as sand. If we mix quarry dust in sand then only 65 to 75 of sand replaced by quarry dust because strength of concrete is
The present paper deals with partial replacement of cement with quarry dust and metakaolin which are having silica used as admixture for making concrete. First quarry dust is made partial replacement of cement and found that 25 of partial replacement is beneficial to concrete without loss of standard strength of cement.
Partial Replacement of Sand with Quarry Dust in Concrete557 . International Journal of Innovative Technology and Exploring Engineering IJITEE ISSN 2278-3075, Volume-2, Issue-6, May 2013 Partial Replacement of Sand with Quarry Dust in Concrete Chandana Sukesh, Katakam Bala Krishna, P.Sri Lakshmi Sai Teja, S.Kanakambara Rao Abstract...
Over the past few years, there have been made many research efforts concerning the utilization of quarry dust as sand substitution material partial or total replacement for the production of several types of concrete and building elements 1,3,4,5,6,7,8,9,10,11,12,13,14.However, the usage of quarry dust in these applications is rather demanding with regard to compositional aspects.
Concrete Cube Made by Using Quarry Dust. The concrete cubes are prepared by using replacement of 10, 20, and 30 of quarry dust. These cubes are tested for compressive strength at 3, 7 and 14 days. Three cube specimens were tested at 3, 7, and 14 days in each percentage and obtained the compressive strength. 6.
found that the compressive and flexural strength of concrete made of Quarry Rock Dust are nearly 10 more than the conventional concrete Suribabu et al., 2015. In the present study it is proposed to investigate the optimum replacement of river sand with stone dust for concrete in term of compressive strength performance at 7 days and 28 days. II.
The paper aims to analyze the compressive strengths of concrete cubes made from quarry dust, sand, and a mixture of sand and quarry dust. The research study adopted is purely laboratory based. A total of 60 grade C20 concrete cubes of size 150 mm 150 mm 150 mm were cast and cured with a constant watercement ratio of 0.5.
International Journal of Engineering Trends and Applications IJETA Volume 5 Issue 3, May-Jun 2018 ISSN 2393-9516 www.ijetajournal.org Page 57 Partial Replacement of Fine Aggregates with Quarry Dust and Marble Powder in Concrete
Quarry Rock Dust as hundred percent substitute for Natural Sand in concrete. Design Mix for M30 and M40 has been calculated using IS 10262-2009 for both conventional concrete and quarry dust concrete. Tests were conducted on cubes, cylinders and prisms to study the strength of concrete by using Quarry Rock Dust and the results were compared
Oct 08, 2020 Properties of micro fine quarry dust concrete. International Journal of Technology and Engineering Studies, 11, 813. Google Scholar Rajput, S. P. S. 2018. An experimental study on crushed stone dust as fine aggregate in cement concrete. Materials Today ...
2. The physical and chemical properties of quarry dust satisfy the requirements of fine aggregate. 3. It is found that quarry dust improves its mechanical property of concrete if used along with super plasticizer. 4. Usage of quarry dust it will also reduce the cost of concrete because it
-The reduction in the sources of natural sand and the requirement for reduction in the cost of concrete production has resulted in the increased need to identify substitute material to sand as fine aggregates in the production of concretes especially in Concrete. Quarry dust, a by-product from the crushing process during quarrying activities is one of such materials.
is higher than the conventional concrete. The durability of quarry rock dust concrete under sulphate and acid action is higher than the conventional concret. Similarly water Absorption found to be more in the concrete containing crusher dust2. The overall workability value of quarry rock dust concrete in terms of slump as well as
Quarry dust gives strength to concrete. In the present study fine aggregate has been replaced by quarry dust. The present work is undertaken to investigate the strength tests, rapid chloride permeability test and corrosion resistance properties of the quarry dust replaced concrete
For this concrete mix, quarry dust was added for replacement of sand from 0 to 100 in step of 10. International Journal of Scientific and Research Publications, Volume 3, Issue 12, December 2013 2
BRITISH for both conventional concrete and quarry dust concrete. Tests were conducted on cubes and beams to study the strength of concrete made of Quarry Rock Dust and the results were compared with the Natural Sand Concrete. An attempt has also been made to durability studies on Quarry Rock Dust when compared with the Natural Sand concrete.
concrete mix and quarry dust will be used as a fine aggregate. The gravity quarry dust is replaced by sand varying different percentage 0, 15, 30, 45, 60 amp 75. then test data of quarry dust concrete will be compared with test data from a standard concrete without quarry dust Keywords Quarry, water cement ratio, compressive
The cement and quarry dust are both suitable for general purpose concrete works. Table 1 Chemical Properties of cement and Quarry dust used Component CaO Al 2 O 3 SiO 2 Fe 2 O 3 SO 3 Cl MgO TiO 2 K 2 O LOI Cement 64.34 4.51 20.79 2.64 1.48 0.03 1.66 - 1.26 1.7 Quarry dust 2.43 16.72 65.66 3.92 - - 3.56 2.21 0.88 -
was studied with various proportions of quarry dust CM 13, CM 12, and CM 11. The experimental results showed that the addition of quarry dust for a fine to coarse aggregate ratio of 0.6 was found to enhance the compressive properties as well as elastic modulus. Key words Concrete, quarry dust, fillers, elastic modulus, compressive strength.
The cost of concrete decreased with the addition of waste. 5 of plastic waste in concrete and 3 of paper pulp, and 5 of fly ash is considered the optimal replacement percentage. Keywords slump cone, split tensile, compressive strength, fly ash, quarry dust, plastic waste, paper waste. References Shyam, S., Drishya, P. 2018.
In this regard, this study proposes to partially replace cement with aluminum dross and fly ash, and partially replace natural sand with quarry dust. Aluminum dross, cement, sand, and quarry dust were used in a variety of proportions with a constant percentage of fly ash for the design of nine concrete
2.1 Quarry rock dust The Quarry Rock Dust obtained from local resource Sri Kanaka Durga Fal-G Brick products, Visakhapatnam was used in concrete to cast test cubes and beams. The physical and chemical properties of Quarry Rock Dust obtained by testing the samples as per Indian Standards are listed in Tables 1 and 2, respectively.
Aug 29, 2018 Rai Baboo, Kumar Sanjay and Satish Kumar 2014 Effect of Fly Ash on Mortar Mixes with Quarry Dust as Fine Aggregate Journal of Adavnces in Material Science and Engineering 1 1-7 2 Krishnamoorthi A and Mohan Kumar G 2013 Properties of Green Concrete Mix by Concurrent use of Fly ash and Quarry dust IOSR Journal of Engineering 3 48-54
May 19, 2020 Quarry dust can be used as an admixture in concrete efficiently to lessen its impact on environment and human. It can also be used as partial replacement of cement in concrete. Cement can be replaced partially by quarry dust in percentage by
Use of Quarry Dust to Replace Sand in Concrete An Experimental Study IJSRP Journal I. INTRODUCTIONoncrete is the most widely used composite material today.
Use of Quarry Dust to Replace Sand in Concrete An Experimental Study329 . For this concrete mix, quarry dust was added for replacement of sand from 0 to in step of 10. www.ijsrp.org International Journal of Scientific and Research Publications, Volume 3, Issue 12, December 2013 ISSN 2250-3153 2 B...